Product ID:G-2 AEROSOL SPRAY LINE-1 (PAINTS), G2B100
MSDS Date:08/01/1992
FSC:8010
NIIN:00N054713
MSDS Number: BVYSC

SHERWIN-WILLIAMS CO

101 PROSPECT AVE N W
CLEVELAND, OH 44115
US

Emergency Phone: 216-566-2917

Info Phone: 216-566-2902

Cage: 54636

SHERWIN-WILLIAMS CO THE

CLEVELAND, OH 44115-1042 US

Telephone: 800-251-2486/216-566-2242

Cage: 54636

760.

CAS: 74-98-6

RTECS: TX2275000

Fraction By Weight: 15%

OSHA PEL 1000 PPM

ACGIH TLV: ASPHYXIANT

760.

CAS: 75-28-5

RTECS: TZ4300000

Fraction By Weight: 15%

OSHA PEL N/K

ACGIH TLV: N/K

22.

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 5%

OSHA PEL 200 PPM

ACGIH TLV: 50 PPM, S

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

7.1.

CAS: 100-41-4

RTECS: DA0700000

Fraction By Weight: 2%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM;125 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

5.9.

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 13%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM;150 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

100.

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: 45%

OSHA PEL 1000 PPM

ACGIH TLV: 750 PPM;1000 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

PROPIONIC ACID, 3-ETHOXY-, ETHYL ESTER;

CAS: 763-69-9

RTECS: UF3325000

Fraction By Weight: 5%

OSHA PEL N/K

ACGIH TLV: N/K

TOLUENE APPEARS ON NAVY LIST OF

RTECS: 9999999ZZ

HLTH PROFESSIONALS CONCERNING LATEST HAZ LIST INFO &

RTECS: 9999999ZZ

INCIN/EXPOS TO TEMP >120F. HEAT FROM SUNLIGHT,

RTECS: 9999999ZZ

COULD CAUSE CNTNR TO BURST. DO NOT TAKE INTERNALLY.

RTECS: 9999999ZZ

AVOID BRTHG VAP & SPRAY MIST. AVOID CONT W/SKIN &

RTECS: 9999999ZZ

NUISANCE PARTICULATES WHICH MAY BE PRESENT AT HAZ

RTECS: 9999999ZZ

NO SPECIFIC DUSTS ARE LISTED IN ING SECTION, APPLIC

RTECS: 9999999ZZ

OSHA PEL 15 MG/M3 TDUST; 5 MG/M3 RESP.

RTECS: 9999999ZZ

MSHA APPRVD PARTICULATE RESP FOR PROT AGAINST

RTECS: 9999999ZZ

1910.94, 1910.107, 1910.108.

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EXPOS MAY BE BY INHAL &/OR SKIN/EYE
CONT, DEPENDING ON CNDTNS OF USE. TO MIN EXPOS, FOLLOW RECS FOR
PROPER USE, VENT & PERSONAL PROT EQUIP. ACUTE:IRRIT OF EYES, SKIN &
RESP SYS. MAY CAUSE NERV SYS DEP RESS. EXTREME OVEREXP MAY RSLT IN
UNCON& POSS DEATH. HDCH, DIZZ, NAUS & LOSS OF COORD ARE INDICATIONS
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:OF EXCESSIVE EXPOS TO VAPS/SPRAY
MISTS. REDNESS & ITCH/BURNING SENSATION MAY INDICATE EYE/EXCESSIVE
SKIN EXPOS. CHRONIC:PRLNG OVEREXP TO SOLV INGS MAY CAUSE ADVERSE
EFTS TO LIVER, URINARY, BL OOD-FORMING, CVS & REPRO SYS. RPTS
HAVEASSOC RPTD & PRLNG OVEREXP TO SOLVS W/PERM BRAIN & NERV SYS
DMG. (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.

First Aid:INHAL:IF ANY BREATHING PROBLEMS OCCUR DURING USE, LEAVE AREA
& GET FRESH AIR. IF PROBLEMS REMAIN OR OCCUR LATER, IMMEDIATELY GET
MEDICAL ATTENTION. SKIN:WASH AFFECTED AREA THOROUGHLY W/SOAP &
WATER. R EMOVE CONTAMINATED CLOTHING & LAUNDER BEFORE RE-USE.
EYES:FLUSH W/LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTENTION. INGEST:GET MEDICAL ATTENTION.

Flash Point:<21F,<-6C
Lower Limits:0.5%
Upper Limits:12.8%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
WATER SPRAY MAY BE INEFT. IF WATER IS USED, FOG NOZZ ARE PREF.
WATER MAY BE USED TO COOL CLSD CNTNRS(SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPKS & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT. APPLICATION TO HOT SURFS(SUPDAT)

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DOL STOR CATEGORY - 1A. CONTENTS ARE
EXTREMELY FLAMM. KEEP AWAY FROM HEAT, SPKS & OPEN FLAME. CONSULT
NFPA CODE. USE APPRVD BONDING & GROUNDING PROCS.
Other Precautions:DURING USE & UNTIL ALL VAPS ARE GONE: KEEP AREA
VENTILATED; DO NOT SMOKE; EXTING ALL FLAMES, PILOT LIGHTS &
HEATERS; TURN OFF STOVES, ELEC TOOLS & APPLIANCES & ANY OTHER
SOURCES OF IGNIT. CONTENTS UND ER PRESS. DO NOT PUNCTURE, (ING 10)

Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMS BY VENT, WEAR PROPERLY FITTED NIOSH/MSHA APPRVD ORG
VAP/PARTICULATE RESP FOR PROT AGAINST INGS. WHEN SANDING,
WIREBRUSHING, ABRADING, BURNING/W ELDING DRIED FILM, WEAR NIOSH/
(ING 16)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPT IF EXPOS TO INGS IS
MAINTAINED BELOW APPLIC EXPOS LIMS. REFER TO OSHA STDS (ING 17)
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC:TO PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN
EXPOS TO EXTREME HEAT. EXPLO HAZ:REQS SPECIAL PRECS. DURING EMER
CNDTNS OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE
IMMED APPARENT. OBTAIN MED ATTN. EFTS OF OVEREXP:INTENTIONAL
MISUSE BY DELIB CONC & INHALING CONTENTS CAN BE (ING 8)

Boiling Pt:B.P. Text:<0F,<-18C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:>75

Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS IN INGS.

Waste Disposal Methods:WASTE FROM THIS PROD MAY BE HAZ AS DEFINED UNDER
RCRA 40 CFR 1910.261. WASTE MUST BE TESTED FOR IGNITABILITY TO
DETERM APPLIC EPA WASTE NUMBERS. DO NOT INCIN. DEPRESSURIZE CNTNR.
DISP OF I/A/W FED, ST ATE & LOC REGS REGARDING POLLUTION.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.